how about this. If you don't make it to h2o you'll have to post 20 pics of the car..... That'll encourage you to finish the damn thing.

__________________
Welcome to the internet:
Where men are men, women are men, and little girls are FBI agents.

agreed

you guys suck

__________________
no new friends

here's a lesson for you kiddies.
KW V3's dont go low
:/
H&R Ultra Ultra's on their way.....
(2) Weber 45's on their way...


goddamn i am lucky i have a good job

__________________
no new friends

..and unlucky with mk1's :/

__________________
no new friends

wanna help fund my truck

the v3´s go low enough when you are on 16´s.
they are made for actual suspension not for beeing stup hard
nobody has bad luck with mk1´s- they just have their own minds
belive me i know...
good for you that you have a good job, now stop whining and post some pics
of what was not low enough...

Jens, you got my pic right?

__________________
no new friends

Wow. the carbs were so done you had to order new ones? Yikes!

couldn't get large jets to do squat (richen it up). kept running lean even with 60F9s on a stock motor. that would be way rich on my motor which is stock minus the cams.

I scratched my head many times.

__________________
79 golf gti wannabe.

i so fucking hope this fixes this issue or no H20 for Louise

__________________
no new friends

Any good news Paulipoos?

Steve I wont be able to get to the UPS store or get to the 78 until next Thursday. Cutting it so close its not funny.

__________________
no new friends

Where is the "biting my nails" icon when I need it.

Wish your 78 was on RJ's and my way to OC. We would be there in a heart beat to help. I'd rather help you get Louise going than to drink beer Thursday and Friday.

Wait, what did I just say?

you just said some very kind words - thanks!

again i just hope we can get something fixed. car wont go into storage until i get it all sorted and i cant/wont work on my tdi until i do so..... and i really need to be driving the tdi right now.......................

__________________
no new friends

Just so you have this and not forget it.

swapping carbs:

1. Remove linkage pin from lower ball socket joint (little clip that hooks over that keeps the joints from seperating) do not be rough with the ball and socket joint. the ball will break easily.

2. Remove three screws that secure your top linkage to carb top (right carb)
3. Remove remaining two screws on right carb top and five screws from left carb (careful with the floats)
4. Move carb tops and top linkage out of the way

You can swap to the new floats from your new carbs at this time. adjust the float level.

5. Sop out remaining fuel form carbs
6. Remove the 8 nuts that hold the carbs to the manifold (do not lose the washers or spring washers if they have them
7. pull the carbs from the manifold studs (do not lose the gaskets and their rubber rings
8. You may need to remove the trumpets from the carbs to allow for clearance first
9. Decide which carb you want on which side.........shouldn't matter
10. Install the linkage (sync scew and idle screws) on the new carbs.
11. There are flanges that bend over the butterfly nuts that keep them from turning. bend them and remove the nuts and reinstall them.
12. Mount the gaskets and make sure the O-rings don't fall out of place
13. Slide the new carbs on and install the nuts (do not over tighten)
14. The sync linkage should be fitting together now. don't worry about adjusting yet
15. Install the tops from your old carb (chrome ones you moved out of the way)
16. install the top linkage that you moved out of the way.
17. Hook up the section of linkage from the old carbs to the lower linkage.
18. insert the clip that holds it on.

double check everything.

while you have your carb tops off, check the float level.


Bottom left is the DCOE. you have square floats but they are about the same

__________________
79 golf gti wannabe.

^woah, information overkill

paul you just have to do it!
get her done
i didnt get the pic though, so you have to come with louise that i can see her

Paul understands why I posted a book of info much easier for him to just read it then for me to explain it to him.

__________________
79 golf gti wannabe.

oh, and when you get it running for h2o. change the oil. I'm sure there has been a lot of fuel getting into the oil.

And bring your assless chaps again

__________________
79 golf gti wannabe.

hey tom are you brnging your car to h2o as well??
joining us for the last leg of the c2c trip?